Here is the entire process I currently use to make my pies at The Garage
Here is how I make my dough: http://www.pizzamaking.com/forum/index.php/topic,20477.msg202047.html#msg202047Here is how I bulk Ferment: http://www.pizzamaking.com/forum/index.php/topic,18509.msg179991.html#msg179991Getting the oven ready:First, I open a nice bottle of wine - red seems to work best. To get the most out of my WFO, I have to get it 1) hot and 2) saturated with heat. They are not the same thing. I can get the floor up to 800F and the dome to over 1000F in perhaps 3-4 hours. Maybe less, but the walls will only be 600-700F or so at the most. This is hot but not saturated.
My best pies are baked with heat coming as evenly as possible from 1) the fire, 2) the ceiling, and 3) the walls. If the bulk of the heat is coming from the fire, the edges will burn before the top browns, and I probably won’t get nice leoparding. This is because I will have to bake closer to the fire. I want to bake up near the wall that is farthest from the fire (I generally put the fire in the back left corner though it would probably be easier for me to work the peel if it was in the back right corner as I’m right handed).
I like to bake when the deck is about 875F and the walls are 925F+. The dome will be well in excess of 1200F. It will take me at least 10 hours of pre heating to achieve this or even close to it, and I usually stick a 500,000BTU torch in the door for 20 minutes at the beginning to kick things off. It would be so much simpler if I could use the oven every day – starting the day with a hot oven. I use larger (4-6" wide logs for the warm-up and smaller 1-2" wide logs for the bake. The large logs burn longer, but the small logs burn hotter. Bake times are 55-65 seconds typically. Ideally, I have enough heat saturation in the walls and dome that I can run a fire that is not too big. The bigger the fire, the more heat coming from the fire, and the harder it is to get an even bake and avoid charred rims. Notwithstanding, I ALWAYS have flames rolling across the top of the dome when I bake.
Making and baking the pie:When I open my dough balls, I am very gentle - no slapping or beating it - and, I always protect the cornice. The top of the dough ball becomes the top of the pizza skin. My dough is very easy to open. I usually press it out with the underside of my fingers – taking care not to use my fingertips. Using light pressure, I start inside of the cornice by about ½” – ¾” and work down protecting and forming the cornice all the way around. I flip it once and press again the same way. Then, I stretch it over my knuckles until it is about 12-13”. To do this, I place the skin over my knuckles and turn it 360 degrees pulling slightly apart with my hands but mostly using gravity. This takes about 5 seconds. I never slap and stretch or anything like that.
“Slap for show, gentle for great dough.” I top the skin quickly (have everything ready and handy), slide the (lightly floured) peel under and stretch out the dough until it is just a bit over 13”. Be sure it’s not hanging over the back edge of your peel at all. Then it’s into the oven.
I launch the pie to a spot near a wall farthest from the fire, after 20 seconds or so, I use my round turning peel to loosen it from the deck and then turn it about 1/3. I generally turn a pie about 3 times on the deck then for the last 10 seconds, I pick it up and dome it right under the flames for a couple seconds. I spin it about 1/3 as I lower it back down then dome it again and so on a couple more times.
Here is how I prep my cheese: http://www.pizzamaking.com/forum/index.php/topic,20455.msg201652.html#msg201652Here is how I make Calabrian chili oil (indispensable): http://www.pizzamaking.com/forum/index.php/topic,19368.msg189521.html#msg189521My sauce:My sauce is about as simple as it gets. It's a 35oz can of Cento Italian whole peeled tomatoes run through a food mill with the coarse plate (everything in the can except the basil leaf), a little less than 1Tbsp sugar (to taste based on the specific can of tomatoes - we generally start at ~1/2Tbs and work up if it needs it), and about 1tsp sea salt (again to taste - start with a little less and add more if it needs it). I always taste the tomatoes after they go through the food mill but before we add anything. Sometimes you get a really sweet can that doesn't need any sugar.
That’s everything I think.
I hope this helps. I’m happy to help with any specific questions about what I wrote here or other things I might have left out.
The Garage:
http://www.pizzamaking.com/forum/index.php/topic,14249.msg182811.html#msg182811